■ 應用 ApplicAtion
◎ 能滿足根、莖、葉類條狀、塊狀、片狀、大顆粒狀等蔬 菜物料的干燥和大批量連續生產，同時能zui大限度的保留 產品的營養成份及顏色等。
◎ 干燥的典型物料有：蒜片、南瓜、胡蘿卜、魔芋、山 藥、竹筍、辣根、洋蔥、蘋果等。
◎ It can meet to dry different vegetables such as, root, halm, leaf, tuberous root, big granule and produce in batch. Meanwhile it can maintain content of nutrition, color, etc of vegetable in most extent.
◎ the type raw materials are garlic, cushaw, giantarum, white turnip, yam, bamboo shoot, capsicum, onion, apple, etc.

■ 原理 principle
◎ 蔬菜脫水干燥機分別有加料器、干燥床、熱交換器及排 濕風機等主要部件組成。
◎ 干燥機工作時，冷空氣通過熱交換器進行加熱,采用科學 合理的循環方式，使熱空氣穿流通過床面上的被干燥物料 進行均勻的熱質交換，機體各單元內熱氣流在循環風機的 作用下進行熱風循環，zui后排出低溫高濕度的空氣，平穩 高效地完成整個干燥過程。
◎ When operation, air will be entered into the dryer and heated through heat exchanger. Being adapted scientific and reasonable cycle method, the hot air will pas through raw materials to be dried on the bed and carry out uniform heat exchange.
◎ under the action of cycle fan, the hot air stream inside each unit of the dryer will carry out hot air cycle. Final air with low temperature and high damp will be out. The whole drying process with stably and high effect will be finished.

■ 特點 FeAtUres
◎ 干燥面積、風壓、風量、干燥溫度網帶運轉速度均可調 節，以適應蔬菜的特性及品質要求。
◎ 可根據蔬菜特點，采用不同的工藝流程及添加配套必要 的輔助設備。
◎ Its dry area, air pressure, air amount, dry temperature and speed of net belt can be adjusted in order to suitable for different characteristics of vegetable and the requirement of quality.
◎ It can adapt different process and equip necessary auxiliary equipment in accordance with different characteristics of vegetable

■ 技術參數 technicAl pArAMeters

注：1、將上表中同一規格的網帶干燥機加料臺，中間臺，出料臺三臺串聯使用，保證蔬菜脫水干燥生產工藝要求，顯著提高產量，有效 保證產品品質。
2、設備高度不包括風機、風管高度
Notes: 1） When make fed table, middle table and discharge table with same specification mentioned above in series for use, it can form the process requirements of production line for vegetables dehydration and raise the output obviously and guarantee the quality of products effectively.
2） the height of equipment does not include the height of fan and air duct.


注：圖為三臺串聯形成式的蔬菜脫水干燥生產線，用于蔬菜脫水干燥生產時一般采用二臺或二臺以上串聯使用所得產品質量較 好。
Notes: Fig. 3 is production line for vegetables dehydration. It consists of 3 sets of dryer in series. In general, it adapts 2 sets or over 2 sets in series, the good quality of products can be got.